机器人用直驱永磁电机研究与发展综述

doi:1004-7018-46-7-81-85

微特电机 ›› 2018, Vol. 46 ›› Issue (7): 81-85.doi: 1004-7018-46-7-81-85

机器人用直驱永磁电机研究与发展综述

郭有权¹,司纪凯¹,刘群坡¹,李应生²,曹文平³

^1. 河南理工大学,焦作 454003
^2. 郑州润华智能设备有限公司,郑州 450001
^3. 阿斯顿大学,伯明翰 B47ET,UK

收稿日期:2017-03-23 出版日期:2018-07-28 发布日期:2018-07-28
作者简介:郭有权(1991—),男,硕士研究生,研究方向是运动驱动与控制。
基金资助:
国家自然科学基金项目(U1361109);国家自然科学基金项目(51777060);河南省自然科学基金项目(162300410117);河南理工大学创新团队(T2015-2)

An Overview on Developments and Researches of Direct Drive Permanent Magnet Machines for Robots

GUO You-quan¹,SI Ji-kai¹,LIU Qun-po¹,LI Ying-sheng²,CAO Wen-ping³

^1. Henan Polytechnic University,Jiaozuo 454003,China
^2. Zhengzhou Runhua Intelligent Equipment Co.,Ltd.,Zhengzhou 450001,China
^3. University of Aston,Birmingham B47ET,UK

Received:2017-03-23 Online:2018-07-28 Published:2018-07-28

摘要/Abstract

摘要：

直驱永磁电机以其直接驱动负载、低损耗、高力矩密度和高控制精度等优越性能,成为机器人直驱系统的重要设备之一。介绍了机器人用各类直驱永磁电机的拓扑结构、工作原理以及国内外的研究现状,剖析了直驱永磁电机的设计分析方法、控制技术以及分析了各自优缺点,展望了机器人直驱式永磁电机未来的研究发展趋势。

关键词: 直驱永磁电机, 径向磁通永磁电机, 轴向磁通永磁电机, 横向磁通永磁电机, 拓扑结构, 设计分析方法

Abstract:

The direct drive permanent magnet motor is one of the important equipment of the robot direct drive system, which has the merits of direct load, low loss, high torque density, high control accuracy, etc. The basic structures, working principles and research status of different direct drive permanent magnet motors for robots were introduced. The design and analysis methods as well as the control theories were presented and its advantages and disadvantages were also analyzed. The research direction of the robot direct drive type permanent magnet moto in the futurer was discussed.

Key words: direct drive permanent magnet motor, radial flux permanent magnet motor, axial flux permanent magnet motor, transverse flux permanent magnet motor (TFPM), topology, design and analysis method

中图分类号:

TM351

郭有权, 司纪凯, 刘群坡, 李应生, 曹文平. 机器人用直驱永磁电机研究与发展综述[J]. 微特电机, 2018, 46(7): 81-85.

GUO You-quan, SI Ji-kai, LIU Qun-po, LI Ying-sheng, CAO Wen-ping. An Overview on Developments and Researches of Direct Drive Permanent Magnet Machines for Robots[J]. Small & Special Electrical Machines, 2018, 46(7): 81-85.

参考文献

[1]	谭民, 王硕 . 机器人技术研究进展[J]. 自动化学报, 2013,39(7):963-972.
[2]	林凯 . 基于真空机器人的直驱电机控制方法的研究[D]. 沈阳:沈阳理工大学, 2010.
[3]	贾帅 . 工业机器人直接电驱动技术研究[D]. 太原:中北大学, 2015.
[4]	杨萌, 韦忠朝, 高信迈 , 等. 港口起重用低速大扭矩电机的优化设计[J]. 湖北工业大学学报, 2012,27(1):66-69.
[5]	YUEJIN Z, LIBING J, CHUNJIANG L , et al. Semi-analytical method for air-gap main magnetic field computation of direct drive permanent magnet torque motors [C]//International Conference on Electrical Machines and Systems.IEEE, 2011: 1-4.
[6]	叶鹏, 江思敏, 林海 , 等. 基于复杂工况的直驱永磁同步电机应用研究[J]. 微电机, 2015,48(12):28-31.
[7]	范玉彬, 于海生 . 二自由度机器人关节的永磁同步电机伺服控制[J]. 青岛大学学报(工程技术版), 2016,31(2):53-58.
[8]	XU L, LIU G, ZHAO W , et al. High-performance fault tolerant halbach permanent magnet vernier machines for safety-critical applications[J]. IEEE Transactions on Magnetics, 2016,52(7):1-4.
[9]	ZHAO W, KWON B, LIPO T A . Development and test of a dual-stator,spoke-type ferrite permanent magnet motor with high torque performance for direct-drive applications [C]//International Symposium on Power Electronics,Electrical Drives,Automation and Motion (SPEEDAM).IEEE, 2016: 104-109.
[10]	DÜCK P, LESNIEWSKI P, PONICK B . Design and analysis of axial-flux permanent magnet synchronous machines as traction drives for electric vehicles [C]//International Sympositium on Power Electronics,Electrical Drives,Automation and Motion.IEEE, 2016: 376-381.
[11]	XIE H, WEI X, LIU Y , et al. Research of asymmetrical bidirectional magnet skewing technique in modular multi-stage axial flux permanent magnet synchronous motor[J]. IEEE Transactions on Magnatics, 2015,51(3):1-5.
[12]	LI W, CHAU K T . Design and analysis of a novel linear transverse flux permanent magnet motor using HTS magnetic shielding[J]. IEEE Transactions on Applied Superconductivity, 2010,3(20):1106-1109.
[13]	包广清, 李战明, 施进浩 . 一种新型组合式横磁通永磁风力发电机[J]. 中国电机工程学报, 2012,32(3):83-88.
[14]	白海军, 张延华 . 新型外永磁转子横向磁通爪极电机特性仿真[J]. 微电机, 2013,42(6):5-8.
[15]	CHOI H S, LEE S H, PARK I H . General formulation of equivalent magnetic charge method for force density distribution on interface of different materials[J]. IEEE Transactions on Magnatics, 2005,5(41):1420-1423.
[16]	李琛, 章跃进, 周晓燕 , 等. 定子开槽表贴式永磁电机转子偏心空载气隙磁场全局解析法[J]. 电机与控制学报, 2014,18(10):27-35.
[17]	任俊杰, 刘彦呈, 赵友涛 , 等. 船用大功率永磁电机矢量控制方案的比较[J]. 电机与控制学报, 2011,15(6):32-37.
[18]	王斌, 王跃, 郭伟 , 等. 基于定子磁链降阶状态观测的永磁同步电机无差拍直接转矩控制系统[J]. 电工技术学报, 2014,29(3):160-171.
[19]	FOO G H B, ZHANG X . Constant switching frequency based direct torque control of interior permanent magnet synchronous motors with reduced ripples and fast torque dynamics[J]. IEEE Transactions on Power Electronics, 2016,9(31):6485-6493.
[20]	张二伟 . 低速大转矩横向磁通永磁同步电机控制系统的研究[J]. 沈阳:沈阳工业大学, 2012.

机器人用直驱永磁电机研究与发展综述

An Overview on Developments and Researches of Direct Drive Permanent Magnet Machines for Robots

RichHTML

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 4

编辑推荐

Metrics

本文评价

联系我们

[1]	张嘉易, 李荣辉, 郝永平. 一种预设转角转速的曲线S实时控制算法[J]. 微特电机, 2020, 48(8): 46-50.
[2]	刘福贵, 李宁宁, 杨乾坤, 罗丹. 双C型定子横向磁通永磁电机的优化设计[J]. 微特电机, 2020, 48(6): 14-16.
[3]	. 轴向磁通永磁电机转子支架涡流损耗研究[J]. 微特电机, 2019, 47(10): 16-20.
[4]	吴伟, 司纪凯, 岳帅军, 刘群坡, 封海潮, 李应生. 多自由度平面感应电机发展综述[J]. 微特电机, 2018, 46(8): 88-92.