小型五相感应电机设计及槽数选取分析

微特电机 ›› 2020, Vol. 48 ›› Issue (6): 28-32.

小型五相感应电机设计及槽数选取分析

熊义勇, 赵镜红

海军工程大学电气工程学院,武汉 430033

收稿日期:2020-04-07 出版日期:2020-06-28 发布日期:2020-06-22
作者简介:熊义勇(1989—),男,硕士,助教,研究方向为电力集成技术。
基金资助:
湖北省自然科学基金创新群体项目(2018CFA008)

Design of Small Five Phase Induction Motor and Slot Number Selection

XIONG Yi-yong, ZHAO Jing-hong

School of Electrical Engineering, Naval University of Engineering,Wuhan 430033,China

Received:2020-04-07 Online:2020-06-28 Published:2020-06-22

摘要/Abstract

摘要： 针对某小型五相感应电机基于磁路法开展初步设计,利用Ansoft软件对电机槽型进行了优化设计,并介绍了通过绕组函数法计算其电感参数的方法;针对小型五相感应电机中定转子槽数进行了筛选,针对定子20槽、30槽、40槽、转子26槽的电机分别进行了仿真分析,验证了设计的合理性,从起动转速、定子电流、径向气隙磁密的仿真对比分析,得出定子40槽可以作为转子26槽的小型五相电机优选的结论。

关键词: 感应电机, 设计, 定转子, 槽数

Abstract: The primary design of a small five phase induction motor was carried out based on the magnetic circuit method. The slot type of the motor was optimized by Ansoft software, and the method of calculating its inductance parameters by winding function method was introduced. The selection of slot number of stator and rotor in the small five phase induction motor was screened and analyzed. For the motor with 20 slots, 30 slots, 40 slots in the stator and 26 slots in the rotors simulation was cunducted. The simulation analysis verified the rationality of the design. From the comparative analysis of the simulation of starting speed, stator current and radial air gap magnetic density, the conclusion is that the stator of 40 slots can be used as the small five phase motor with 26 slots of rotor.

Key words: induction motor, design, stator and rotor, slot number

中图分类号:

TM343+.3

熊义勇, 赵镜红. 小型五相感应电机设计及槽数选取分析[J]. 微特电机, 2020, 48(6): 28-32.

XIONG Yi-yong, ZHAO Jing-hong. Design of Small Five Phase Induction Motor and Slot Number Selection[J]. Small & Special Electrical Machines, 2020, 48(6): 28-32.

参考文献

[1] BARRERO F, DURAN M J. Recent advances in the design, modeling, and control of multiphase machines—Part I[J]. IEEE Transactions on Industrial Electronics, 2016, 63(1):449-458.
[2] DURAN M J, BARRERO F. Recent advances in the design, modeling, and control of multiphase machines—Part II[J].IEEE Transactions on Industrial Electronics, 2016, 63(1):459-468.
[3] 孙俊忠,许伯强.五相异步电动机的设计与参数计算[J]. 电机与控制应用,2017,44(6):84-90.
[4] 陈世坤.电机设计[M].北京:机械工业出版社,1990:24-280.
[5] 李隆年,王宝玲,周汝潢.电机设计[M].北京:清华大学出版社,1992:38-112.
[6] 俞鑫昌.电机、电器优化设计[M].北京:机械工业出版社, 1988:32-78.
[7] 荆超.五相异步电机设计与性能分析[D].哈尔滨:哈尔滨理工大学,2019:5-19.
[8] 陈宇.三次谐波注入下五相感应电机的设计与运行特性研究[D].沈阳:沈阳工业大学,2014:12-34.
[9] 王东,吴新振,马伟明,等.非正弦供电十五相感应电机气隙磁势分析[J].中国电机工程学报,2009,29(15):88-94.
[10] PEREIRA L A, SCHARLAU C C, PEREIRA L F A, et al. Influence of saturation on the airgap induction waveform of five-phase induction machines[J].IEEE Transactions on Energy Conversion, 2012, 27(1):29-41.
[11] ROSA R S D, PEREIRA L A, PEREIRA L F A, et al. Comparison of operating curves of five-phase and three-phase induction machines of same size[C]// Conference of the IEEE Industrial Electronics Society.2015:450-455.
[12] 列维 E.多相电动机直接设计法[M].北京:机械工业出版社,1989:44-87.
[13] 高景德,王祥珩,李发海.交流电机及其系统的分析[M].北京:清华大学出版社,1993:1-82.
[14] 托利冶特.电机建模、状态监测与故障诊断[M].北京:机械工业出版社,2014:33-58.
[15] 鲍晓华,程志恒,王汉丰,等.基于改进绕组函数法的感应电机偏心电感参数计算[J].电工技术学报, 2016,31(6):13-20.
[16] 刘振兴,尹项根,张哲.基于绕组函数的鼠笼式异步电动机电感参数解析计算[J].电力自动化设备, 2004,24(6):26-28.
[17] 付丰礼,唐孝镐.异步电动机设计手册[M].北京:机械工业出版社,2002:35-41.
[18] 黄坚,郭中醒.实用电机设计计算手册[M].上海:上海科学技术出版社,2014:15-22.