电压波动与闪变对异步电动机能效的影响分析

微特电机 ›› 2020, Vol. 48 ›› Issue (4): 32-38.

电压波动与闪变对异步电动机能效的影响分析

陈子辉¹, 刘勇浩¹, 陈积会¹, 吴非²

1.广东电网有限责任公司江门供电局,江门 529000;
2.广东工业大学自动化学院,广州 510006

收稿日期:2019-07-22 出版日期:2020-04-28 发布日期:2020-04-24
作者简介:陈子辉(1976--),男,高级工程师,主要从事电气试验技术应用研究与管理工作.
基金资助:
广东电网有限责任公司科技项目(GDKJXM20172877)

Effect of Voltage Fluctuation and Flicker on Energy Efficiency of Asynchronous Motor

CHEN Zi-hui¹, LIU Yong-hao¹, CHEN Ji-hui¹, WU Fei²

1.Jiangmen Power Supply Bureau of Guangdong Power Grid Co.,Ltd.,Jiangmen 529000,China;
2.School of Automation, Guangdong University of Technology, Guangzhou 510006, China

Received:2019-07-22 Online:2020-04-28 Published:2020-04-24

摘要/Abstract

摘要： 为探究电压波动与闪变时三相异步电动机的损耗特性及能效变化,以一台11 kW的三相异步电动机为例,利用经典等效电路,在电压波动的参数范围内,设定步长,定性,定量分析了异步电动机各项损耗及能效随参数的变化情况.仿真数据表明,电动机能效与波动频率成反比,与波动幅值的平方成反比,且反比于波动频率与幅值的乘积;25 Hz的波动频率点为铜耗,铁耗及能效的突变点.当波动频率大于25 Hz时,负序磁场使定,转子铜耗明显增加,能效下降速度加快,而铁耗始终变化不大.

关键词: 电压波动与闪变, 异步电动机, 间谐波, 等效电路, 损耗, 能效

Abstract: In order to explore the loss characteristics and energy efficiency of the three-phase asynchronous motor under the voltage fluctuation and flicker,an 11 kW three-phase asynchronous motor was used to analyze qualitatively and quantitatively the loss and energy efficieny by classical equivalent circuit with the variation of the voltage fluctuation parameters in a certain step size.The simulations showed that the decrease of efficiency was proportional to the fluctuation frequency, the square of fluctuation amplitude, and the product of frequency and amplitude.The fluctuation frequency of 25 Hz was the abrupt change point of copper loss, iron loss and energy efficiency.When the fluctuation frequency was greater than 25 Hz,the copper loss of stator and rotor was obviously increased with the negative sequence magnetic field,and the decrease of energy efficiency was accelerated. The iron loss does not change much all the time.

Key words: voltage fluctuation and flicker, asynchronous motor, fraction-harmonics, equivalent circuit, loss, energy efficiency

中图分类号:

TM343

陈子辉, 刘勇浩, 陈积会, 吴非. 电压波动与闪变对异步电动机能效的影响分析[J]. 微特电机, 2020, 48(4): 32-38.

CHEN Zi-hui, LIU Yong-hao, CHEN Ji-hui, WU Fei. Effect of Voltage Fluctuation and Flicker on Energy Efficiency of Asynchronous Motor[J]. Small & Special Electrical Machines, 2020, 48(4): 32-38.

参考文献 20

[1]	刘尚伟,吴玲,赵瑞锋,等.基于MTOPSIS-GRA的智能配电网评估方法[J].广东电力,2019,32(2):113-120.
[2]	顾德军,李光耀,汤惠明,等.高压高效率三相异步电动机的开发[J].电机与控制应用,2015,42(5):81-84.
[3]	张元星,赵海森,刘晓芳,等.电压不平衡时异步电机内部磁密与电密分布特点及其对损耗影响[J].电机与控制应用,2014,41(3):6-11.
[4]	安俊义,赵海森,刘晓芳,等.槽配合对单绕组双速直槽异步电动机空载磁场及损耗的影响[J].微特电机,2015,43(5):17-21.
[5]	刘承榆,张威.逆变器供电的笼型异步电动机中损耗和效率计算[J].中小型电机,1991(3):2-8.
[6]	高泽梅,王淑红,武潇,等.PWM供电对永磁同步电动机的性能影响及谐波抑制[J].武汉大学学报(工学版),2017,50(3):395-400.
[7]	张冬冬,赵海森,赵伟波,等.供电电源包含谐波及不平衡共存时感应电机损耗特性[J].电机与控制应用,2016,43(7):45-50.
[8]	PERERA D,MEEGAHAPOLA L,PERERA S,et al.Characterisation of flicker emission and propagation in distribution networks with bi-directional power flows[J]. Renewable Energy,2014(63):172-180.
[9]	MOHAMMADI E,FADAEINDIAD R,RAJI H R,et al.Flicker emission,voltage fluctuations and mechanical loads for small-scale stall- and yaw-controlled wind turbines[J].Energy Conversion and Management,2018(165):567-577.
[10]	MORSI W G,EL-HAWARY M E.On the appropriate monitoring period for voltage flicker measurement in the presence of distributed generation[J].Electric Power Systems Research,2009,79(4):561-577.
[11]	张馨方. 农村电网电压波动对农业机械电动机性能的影响[J].农机化研究,2011,33(1):169-172,178.
[12]	王庆,张蓬鹤,赵海森,等.基于可测电气量鼠笼式异步电机能效在线监测方法[J].微特电机,2013,41(12):26-30.
[13]	SUN Z C,SHEN J X,JIN M J,et al.Research of the influence of different PWM inverters on the iron losses for induction motors[C]//2014 17th International Conference on Electrical Machines and Systems.Hangzhou:IEEE,2014:96-100.
[14]	金焱. 电能质量扰动对异步电动机的影响与分析软件研究[D].北京:华北电力大学,2006.
[15]	张柯,高志强,周雪松,等.非正弦输入下异步电机损耗计算与分析[J].电力系统及其自动化学报,2018,30(5):28-32.
[16]	朱家龙,杜正聪,祝俊.基于多相滤波器组的谐波和间谐波快速检测与分析[J].电测与仪表,2019,56(2):90-96.
[17]	屠金玲. 电压波动与闪变的检测和抑制[D].济南:山东大学,2013.
[18]	于永军,任祖华,罗忠游,等.计及相位影响的间谐波与电压闪变的定量关系研究[J].电测与仪表,2017,54(11):13-18.
[19]	李佳宣,李鹏宇,陈庚,等.基于MATLAB/Simulink的变频电机系统能耗实用模型[J].电机与控制应用,2017,44(5):84-89,120.
[20]	傅丰礼,唐孝镐.异步电动机设计手册[M].北京:机械工业出版社,2006:903-905.