九相感应电机切套运行的非线性磁路计算

微特电机 ›› 2020, Vol. 48 ›› Issue (10): 20-23.

九相感应电机切套运行的非线性磁路计算

李永佳, 郑晓钦

青岛大学电气工程学院,青岛 266071

收稿日期:2020-05-26 出版日期:2020-10-28 发布日期:2020-10-22
作者简介:李永佳(1995—),男,硕士研究生,研究方向为多相感应电机性能分析。
基金资助:
国家自然科学基金资助项目(51907093);山东省自然科学基金资助项目(ZR2019BEE009);中国博士后科学基金资助项目(2018M642610)

Calculation of Non-Linear Magnetic Circuit for Nine-Phase Induction Motor Cutting

LI Yong-jia, ZHENG Xiao-qin

College of Electrical Engineering, Qingdao University, Qingdao 266071, China

Received:2020-05-26 Online:2020-10-28 Published:2020-10-22

摘要/Abstract

摘要： 多套多相绕组构成的感应电机发生缺相故障时可以切出故障相所在的整套绕组,电机工作在切套运行状态。为掌握电机切套运行时的精确性能指标,以三套三相绕组构成的九相感应电机为研究对象,应用分布磁路法计算了电机相数和励磁电流均发生变化后的非线性磁路,得到工作范围内励磁电流与励磁电感的对应关系,通过非线性插值即可求得任意励磁电流下计及饱和时的励磁电感。利用有限元法对九相感应电机不同切套工况进行仿真验证,仿真结果与分布磁路法计算结果相吻合,验证了磁路计算结果的正确性。

关键词: 九相感应电机, 切套运行, 分布磁路法, 励磁电感

Abstract: The induction motor composed of multiple sets of multi-phase windings can cut out the entire set of windings where the faulty phase is located when the phase failure occurs, so that the motor works in the cut-to-sleeve operation state. In order to grasp the precise performance index of the motor when the sleeve is running, the nine-phase induction motor composed of three sets of three-phase windings was taken as the research object, and the distributed magnetic circuit approach was used to calculate the nonlinear magnetic field after the change of phase number and excitation current. The corresponding relationship between the excitation current and the excitation inductance in the working range was obtained, and the excitation inductance at any excitation current in consideration of saturation can be obtained by nonlinear interpolation. The finite element method was used to simulate and verify the different cutting conditions of the nine-phase induction motor. The simulation results were consistent with the calculation results of the distributed magnetic circuit method, and the correctness of the magnetic circuit calculation results was verified.

Key words: nine-phase induction motor, operation with sets of winding out of service, distributed magnetic circuit approach, excitation inductance

中图分类号:

TM346

李永佳, 郑晓钦. 九相感应电机切套运行的非线性磁路计算[J]. 微特电机, 2020, 48(10): 20-23.

LI Yong-jia, ZHENG Xiao-qin. Calculation of Non-Linear Magnetic Circuit for Nine-Phase Induction Motor Cutting[J]. Small & Special Electrical Machines, 2020, 48(10): 20-23.

参考文献

[1] 马伟明, 王东, 程思为, 等. 高性能电机系统的共性基础科学问题与技术发展前沿[J]. 中国电机工程学报, 2016, 36(8): 2025-2035.
[2] BARRERO F, DURAN M J. Recent advances in the design,modeling, and control of multiphase machines-Part I[J]. IEEE Transactions on Industrial Electronics,2016, 63(1): 449-458.
[3] DURAN M J, BARRERO F. Recent advances in the design, modeling, and control of multiphase machines-part II[J]. IEEE Transactions on Industrial Electronics,2016, 63(1): 459-468.
[4] LIU Z H, WU J Q,HAO LIANG L.Coordinated and fault-tolerant control of tandem 15-phase induction motors in ship propulsion system[J].IET Electric Power Applications,2018,12(1): 91-97.
[5] ZHENG X Q, WANG D. Torque regulation of multi-phase induction motors under symmetrical fault condition[J]. Transactions of the Institute of Electric Engineers of Japan, 2017, 12(2): 284-291.
[6] 郑晓钦,王东,刘海涛,等.十五相感应推进电机切套减额运行转矩计算[J].电工技术学报,2019,34(1):58-65.
[7] FNAIECH M, BETIN F, CAPOLINO G, et al. Fuzzy logic and sliding-mode controls applied to six-phase induction machine with open phases[J]. IEEE Transactions on Industrial Electronics, 2010,57(1):354-364.
[8] APSLEY JM. Derating of multiphase induction machines due to supply imbalance[J]. IEEE Transactions on Industry Applications 2010,46(2):798-805.
[9] RAMINOSOA T, GERADA C, OTHMAN N, et al. Rotor losses in fault-tolerant permanent magnet synchronous machines[J]. IET Electric Power Applications 2011,5(1):75-85.
[10] 陈世坤. 电机设计[M]. 北京:机械工业出版社,1990.
[11] JUHA PYRONEN, TAPANI JOKINEN. 旋转电机设计[M]. 贾好来,陈燕,潘伟,等译. 北京:国防工业出版社,2016.
[12] 徐衍亮,吴巧变,宫晓.新型盘式横向磁通永磁无刷电机的变网络等效磁路模型[J].电工技术学报,2016,31(17):147-153.
[13] KAPPATOU J , GYFTAKIS C , SAFACAS A . A study of the effects of the stator slots wedges material on the behavior of an induction machine[C]// International Conference on Electrical Machines. 2008: 1-6.
[14] 王荀,邱阿瑞.笼型异步电动机径向电磁力波的有限元计算[J].电工技术学报,2012,27(7):109-117.
[15] 鲍晓华,狄冲,汪朗.笼型感应电机转子斜槽研究综述及展望[J].电工技术学报,2016,31(6):1-12.
[16] 王东,吴新振,马伟明,等.非正弦供电十五相感应电机磁路计算方法[J].中国电机工程学报,2009,29(12):58-64.
[17] WANG D, WU X Z, CHEN J Q, et al. A distributed magnetic circuit approach to analysis of multiphase induction machine with non-sinusoidal supply[J]. IEEE Transactions on Energy Conversion, 2015, 30(2): 58-64.