车用永磁同步电机最大转矩电流比控制研究

微特电机 ›› 2023, Vol. 51 ›› Issue (5): 55-60.

车用永磁同步电机最大转矩电流比控制研究

姚博炜^1,2, 刘志军^1,2, 王国栋¹, 李强¹

1.柳州赛克科技发展有限公司,柳州 545005;
2.柳州市电气化动力总成电子控制重点实验室,柳州 545005

收稿日期:2023-02-23 出版日期:2023-05-28 发布日期:2023-05-29
作者简介:姚博炜(1984—),男,博士,高级工程师,主要从事混合动力车型开发工作。
基金资助:
柳州市科技计划资助项目(2022ABA0105); 柳东新区科技计划资助项目(柳东科攻20210102)

Research on Maximum Torque Per Ampere Control of Permanent Magnet Synchronous Motor for Vehicle

YAO Bowei^1,2, LIU Zhijun ^1,2, WANG Guodong¹, LI Qiang¹

1. Liuzhou Saike Technology Development Co.,Ltd.,Liuzhou 545005, China;
2. Liuzhou Key Laboratory of Electrified Powertrain Electronic Control,Liuzhou 545005, China

Received:2023-02-23 Online:2023-05-28 Published:2023-05-29

摘要/Abstract

摘要： 基于d,q转子坐标系建立了永磁同步电机的数学模型,对比分析了经典的矢量控制方法。与控制逻辑架构简单、且易于实现的I_d=0控制方法相比,最大转矩电流比(MTPA)控制可以充分利用磁阻转矩,减小输出相同转矩下所需电子电流,提高控制系统的效率。弱磁控制通过改变调整交直轴电流来削弱永磁体磁场,使永磁电机能够运行在更高的转速范围。为了实现对交直轴电流的独立控制,提高系统的动态性能,需要进行电流解耦控制,并且分析了反馈解耦的实现方式和特点。将MTPA控制、弱磁控制、电流解耦控制三者结合,可以实现永磁电机在多种工况下的稳定运行。

关键词: 永磁同步电机, 最大转矩电流比控制, 弱磁控制, 电流解耦控制

Abstract: The mathematical model of permanent magnet synchronous motor (PMSM) was established based on the d and q axis rotor coordinate system, and the classical vector control method was compared and analyzed. Compared with the control method of I_d=0 which was simple control logic structure and easy implementation, themaximum torque per ampere (MTPA) control can made full use of the reluctance torque, reduced the stator current required under the same output torque, and improve the efficiency of the control system. The flux weakening control weakened the permanent magnet magnetic field by changing and adjusting the d and q-axis currents, so that the permanent magnet motor could operate in a higher speed range. In order to realize the independent control of the d and q-axis current and improve the dynamic performance of the system, the current decoupling control was required, and the realization methods and characteristics of the feedback decoupling were analyzed. The combination of MTPA control, flux weakening control and current decoupling control realized the stable operation of permanent magnet motor under various working conditions.

Key words: permanent magnet synchronous motor(PMSM), maximum torque per ampere(MTPA) control, field weakening control, current decoupling control

中图分类号:

TM341

姚博炜, 刘志军, 王国栋, 李强. 车用永磁同步电机最大转矩电流比控制研究[J]. 微特电机, 2023, 51(5): 55-60.

YAO Bowei, LIU Zhijun , WANG Guodong, LI Qiang. Research on Maximum Torque Per Ampere Control of Permanent Magnet Synchronous Motor for Vehicle[J]. Small & Special Electrical Machines, 2023, 51(5): 55-60.

参考文献

[1] CHAN C C.The state of the art of electric and hybrid vehicles[C]//Proceedings of the IEEE.2002,90(2):247-275.
[2] 雷将华.并联混合动力汽车模糊逻辑控制策略的研究[D].武汉:武汉理工大学,2013.
[3] CHAN C C.The state of the art of electric,hybrid and fuel cell vehicles[C]//Proceedings of the IEEE.2007,95(4):704-718.
[4] 张兴春.混合动力用内置式永磁同步电机转矩控制研究[D].北京:北京理工大学,2012.
[5] ZHONG L,RAHMAN M F,HU W Y,et al.Analysis of direct torque control in permanent magnet synchronous motor drives[J].IEEE Transactions on Power Electronics,1997,12(3):528-536.
[6] RAHMAN M F,ZHONG L,HAQUE M E,et al.A direct torque-controlled interior permanent-magnet synchronous motor drive without a speed sensor[J].IEEE Transactions on Energy Conversion,2003,18(1):17-22.
[7] ION B,CRISTIAN I P,CRISTIAN L,et al.DTFC-SVM motion-sensorless control of a PM-assisted reluctance synchronous machine as starter-alternator for hybrid electric vehicles[J].IEEE Transactions on Power Electronics,2006,21(3):711-720.
[8] FOO G,RAHMAN M F.Direct torque control of an IPM-synchronous motor drive at very low speed using a sliding-mode stator flux observer[J].IEEE Transactions on Power Electronics,2010,25(4):933-942.
[9] 周雅夫,连静,李骏,等.基于矢量控制的混合动力汽车电机控制器设计[J].汽车电器,2010(7):1-6.
[10] AGUIRRE M,CALLEJA C,LOPEZ-DE-HEREDIA A,et al.FOC and DTC comparison in PMSM for railway traction application[C]//European Conference on Power Electronics and Applications (EPE),2011:1-10.
[11] 满永奎,韩安荣.通用变频器及其应用[M].第3版.北京:机械工业出版社,2012:25-66.
[12] 周兆勇,李铁才,高桥敏男.基于矢量控制的高性能交流电机速度伺服控制器的FPGA实现[J].中国电机工程学报,2004,24(5):168-173.
[13] 王成元,夏加宽,孙宜标.现代电机控制技术[M].北京:机械工业出版社,2009.
[14] 赵争鸣,袁立强,孟朔,等.通用变频器矢量控制与直接转矩控制特性比较[J].电工技术学报,2004,19(4):81-86.
[15] 程博,叶敏,李雪,等.基于模糊矢量及弱磁扩速机理的电动汽车控制研究[J].中国机械工程,2012,23(15):1884-1890.
[16] 祁春清,宋正强.基于粒子群优化模糊控制器永磁同步电机控制[J].中国电机工程学报,2006,26(17):158-163.
[17] 卢东斌,欧阳明高,谷靖,等.电动汽车永磁同步电机最优制动能量回馈控制[J].中国电机工程学报,2013,33(3):83-92.
[18] PEYMAN N,HAMID A T,ABBAS G.Robust maximum torque per ampere (MTPA)control of PM-assisted SynRM for traction applications[J].IEEE Transactions on Vehicular Technology,2007,56(4):1538-1546.
[19] SEBASTIAN T.Temperature effects on torque production and efficiency of PM motors using NdFeB magnets[J].IEEE Transactions on Industry Applications,1995,31(2):353-357.
[20] WIJENAYAKE A H,SCHMIDT P B.Modeling and analysis of permanent magnet synchronous motor by taking saturation and core loss into account[C]//International Conference on Power Electronics & Drive Systems.IEEE,1997:530-534.
[21] MELLOR P H,CHAABAN F B,BINNS K J.Estimation of parameters and performance of rare-earth permanent-magnet motors avoiding measurement of load angle[C]//IEE Proceedings B:Electric Power Applications,1991,138(6):322-330.
[22] 符荣,窦满峰.电动汽车驱动用内置式永磁同步电机直交轴电感参数计算与实验研究[J].电工技术学报,2014,29(11):30-37.