自由活塞内燃机用直线发电机的设计与分析

微特电机 ›› 2020, Vol. 48 ›› Issue (8): 12-17.

自由活塞内燃机用直线发电机的设计与分析

王振华, 胡凯, 肖进

上海交通大学,上海 200240

收稿日期:2019-07-25 出版日期:2020-08-28 发布日期:2020-08-24
作者简介:王振华(1991—),男,硕士研究生,主要研究方向为自由活塞直线发电机。
基金资助:
国家自然科学基金项目(51376116)

Design and Analysis of Linear Generator Used for Free Piston Internal Combustion Engine

WANG Zhen-hua, HU Kai, XIAO Jin

Shanghai Jiaotong University,Shanghai 200240,China

Received:2019-07-25 Online:2020-08-28 Published:2020-08-24

摘要/Abstract

摘要： 自由活塞内燃发电机是一种新型动力装置,该装置中直线发电机的动子运动规律受缸内燃烧状况的影响,动子不同运动规律及永磁体充磁方式均会影响直线发电机的性能。运用有限元法分析动子不同运动规律及永磁体不同充磁方式下直线发电机的空载及负载特性。分析结果表明,匀速运动下感应电动势正弦波形畸变率最小。相同极弧系数下,径向充磁方式下空载定位力幅度比轴向充磁更大、空载反电动势正弦波形畸变率更小。相同负载下,径向充磁方式下的输出功率及动子所受的电磁力均比轴向充磁大。

关键词: 自由活塞, 直线发电机, 动子运动规律, 充磁方式

Abstract: The free piston internal combustion generator is a new type of power plant.The motion of the moving part in the linear generator is affected by the combustion status inside the cylinder.Different motion laws of the moving part and the magnetization mode of permanent magnet will affect the performance of linear generator.The finite element method was used to analyze the unloaded and loaded characteristics of the linear generator with different motion laws of the moving part.The effect of different magnetization modes of permanent magnet on the performance of linear generator was also investigated.The simulation results show that the sine wave distortion rate of the induced electromotive force is the smallest if the linear generator moves with constant velocity.With the same polar arc coefficient,the amplitude of the unloaded detent force under the radial magnetization is greater than that of the axial magnetization, and the sine wave distortion rate of the unloaded back EMF is smaller.With the same load, the output power and the electromagnetic force under the radial magnetization are larger than the axial magnetization.

Key words: free piston, linear generator, motion laws of moving part, magnetization mode

中图分类号:

TM359.4

王振华, 胡凯, 肖进. 自由活塞内燃机用直线发电机的设计与分析[J]. 微特电机, 2020, 48(8): 12-17.

WANG Zhen-hua, HU Kai, XIAO Jin. Design and Analysis of Linear Generator Used for Free Piston Internal Combustion Engine[J]. Small & Special Electrical Machines, 2020, 48(8): 12-17.

参考文献

[1] 张静,刘旭明,陈琦,等.圆筒型Halbach永磁单相直线发电机的设计与分析[J].微特电机,2014,42(8):20-22.
[2] 胡凯,肖进,王金龙,等.内燃机用永磁直线发电机的正交优化与分析[J].微特电机,2018,46(10):24-29,38.
[3] ARSHAD W M, THELIN P, BACKSTROM T, et al. Use of transverse-flux machines in a free-piston generator[J]. IEEE Transactions on Industry Applications,2004,40(4):1092-1100.
[4] ARSHAD W M.A low-leakage linear transverse-flux machine for a free-piston generator[D].Stockholm:Elektrotekniska System,2003.
[5] WANG J,JEWELL G W,HOWE D.A general framework for the analysis and design of tubular linear permanent magnet machines[J].IEEE Transactions on Magnetics,1999,35(3):1986-2000.
[6] WANG J,HOWE D.Analysis of axially magnetised,iron-cored,tubular permanent magnet machines[J].IEE Proceedings-Electric Power Applications,2004,151(2):144-150.
[7] WANG J,HOWE D.Design optimization of radially magnetized, iron-cored, tubular permanent-magnet machines and drive systems[J].IEEE Transactions on Magnetics,2004,40(5):3262-3277.
[8] VAN BLARIGAN P, GOLDSBOROUGH S, PARADISO N, et al. Homogeneous Charge Compression Ignition Free Piston Linear Alternator[R].Sandia National Laboratories, Livermore, CA, 1998.
[9] 李斐斐,薜斌峰,郑萍,等.电动车用径向充磁自由活塞式永磁直线发电机研究[J].微电机,2008,41(2):22-24.
[10] 陈益广,周华,唐明龙,等.内燃机用自由活塞永磁直流直线发电机分析[J].微特电机,2012,40(5):19-22,26.
[11] LI Q, XIAO J, HUANG Z. Flat-type permanent magnet linear alternator:A suitable device for a free piston linear alternator[J].Journal of Zhejiang University-SCIENCE A,2009,10(3):345-352.
[12] 徐岩,冯慧华,毛金龙,等.压燃式自由活塞直线发电机参数匹配设计与工作过程仿真[J].车用发动机,2011(5):12-17.
[13] 袁晨恒,冯慧华,李延骁,等.自由活塞直线发电机总体参数设计方法[J].西安交通大学学报,2014,48(7):41-45,52.
[14] 徐照平. 内燃-直线发电集成动力系统的关键技术研究及其系统实现[D].南京:南京理工大学,2010.
[15] BOLDEA I,NASAR S A.Permanent-magnet linear alternators part 1:Fundamental equations[J].IEEE Transactions on Aerospace and Electronic Systems,1987 (1):73-78.
[16] BOLDEA I,NASAR S A.Permanent-magnet linear alternators Part II: design guidelines[J].IEEE Transactions on Aerospace and Electronic Systems,1987(1):79-82.
[17] 余海涛,施学庆,胡敏强,等.用于海浪发电的圆筒型永磁直线发电机性能分析[J].海洋技术学报,2012,31(4):79-82.