基于三相电流连续的无刷直流电动机驱动技术

doi:1004-7018-46-3-9-13

微特电机 ›› 2018, Vol. 46 ›› Issue (3): 9-13.doi: 1004-7018-46-3-9-13

基于三相电流连续的无刷直流电动机驱动技术

赵君,蔡晓乐

中航工业西安航空计算技术研究所,西安 710065

收稿日期:2017-08-29 出版日期:2018-03-28 发布日期:2018-03-28
作者简介:赵君(1982—),男,高级工程师,博士,研究方向为新型机载机电系统嵌入式智能控制、机电系统综合仿真与评估技术。
基金资助:
航空科学基金-青年基金项目(2014ZD31006)

Research on a Novel Driving Strategy of BLDCM Based on Continuous Three-Phase Current Mode

ZHAO Jun, CAI Xiao-le

AVIC Computing Technique Research Institute, Xi’an 710065, China

Received:2017-08-29 Online:2018-03-28 Published:2018-03-28

摘要/Abstract

摘要：

针对无刷直流电动机在传统“两两导通”驱动方式下存在非换相电流脉动,导致转矩脉动较大和引起电枢绕组铜耗较高的问题,提出一种“三相电流连续”的驱动方法。该方法以电机转矩方程、反电势方程作为约束条件,求解使绕组铜耗最小的电流极值,并将电机转子位置划分为12个扇区,根据扇区将该极值分配到三相给定电流。依据星形绕组三相电流之和为零的原理,可以通过两相电流闭环控制,实现三相电流的连续输出。为验证该驱动方法的可行性与有效性,进行了基于Simulink的建模仿真并搭建实验平台,仿真与实验结果表明该方法可以有效地抑制转矩脉动,同时可以降低电机的绕组铜耗。

关键词: 无刷直流电动机, 三相电流连续, 电流极限解, 转矩脉动抑制

Abstract: Aim

ing at the problem of inactive phase and non-commutation current ripple of brushless DC motor (BLDCM) working with the conventional two-conduction mode, which decreased power density and increased torque ripple of BLDCM, a novel continuous three-phase current driving mode for BLDCM was proposed. The novel driving mode was conducted by taking the torque equation and back EMF equation as the constraints to obtain the current extremum for minimum copper loss. Then the position of rotor was divided into twelve sectors. According to sector sequence, the extremum was designed to be the command of three-phase current in the inner current loop. As the sum of three phase current of Y-connected winding BLDCM is zero, the continuous current output of three phases was implemented by the current closed-loop control of two phases. In order to verify the feasibility and effectiveness of the novel driving mode, both the Simulink simulation model and experiment condition were established. The simulation and experiment results validated that the novel driving mode could restrain the torque ripple, minimize copper loss of BLDCM.

Key words: brushless DC motor (BLDCM), continuous three-phase current, current-limited solution, torque ripple reduction

中图分类号:

TM33

赵君, 蔡晓乐. 基于三相电流连续的无刷直流电动机驱动技术[J]. 微特电机, 2018, 46(3): 9-13.

ZHAO Jun, CAI Xiao-le. Research on a Novel Driving Strategy of BLDCM Based on Continuous Three-Phase Current Mode[J]. Small & Special Electrical Machines, 2018, 46(3): 9-13.

参考文献

[1]	谭建成 . 永磁无刷直流电机技术[M]. 北京: 机械工业出版社, 2011.
[2]	谭博, 马瑞卿, 刘卫国 . 一种永磁无刷直流电动舵机四象限控制[J]. 电工技术学报, 2011,26(9):73-79.
[3]	SHI T, GUO Y, SONG P , et al. A new approach of minimizing commutation torque ripple for brushless DC motor based on DC-DC converter[J]. IEEE Transactions on Industrial Electronics, 2010,57(10):3483-3490.
[4]	VISWANATHAN V, JEEVANANTHAN S . Approach for torque ripple reduction for brushless DC motor based on three-level neutral-point-clamped inverter with DC-DC converter[J]. IET Power Electronics, 2015,1(8):47-55.
[5]	李珍国, 周生海, 王江浩 , 等. 无刷直流电动机双闭环调速系统的转矩脉动抑制研究[J]. 电工技术学报, 2015,30(15):156-163.
[6]	XIA C, WANG Y, SHI T . Implementation of finite-state model predictive control for commutation torque ripple minimization of permanent-magnet brushless DC motor[J]. IEEE Transactions on Industrial Electronics, 2013,60(3):896-905.
[7]	王晓远, 高鹏, 赵玉双 . 电动汽车用高功率密度电机关键技术[J]. 电工技术学报, 2015,30(6):53-59.
[8]	梁培鑫, 裴宇龙, 甘磊 , 等. 高功率密度轮毂电机温度场建模研究[J]. 电工技术学报, 2015,30(14):170-176.
[9]	陈萍, 唐任远, 佟文明 , 等. 高功率密度永磁同步电机永磁体涡流损耗分布规律及其影响[J]. 电工技术学报, 2015,30(6):1-9.
[10]	FAN T, LI Q, WEN X . Development of a high power density motor made of amorphous alloy cores[J]. IEEE Transactions on Industrial Electronics, 2014,61(9):4510-4518.
[11]	KRAHENBUHL D, ZWYSSIG C, WESER H , et al. A miniature 500 000 r/min electrically driven turbocompressor[J]. IEEE Transactions on Industry Applications, 2010,46(6):2459-2466.
[12]	OZPINECI B , CHINTHAVALIMS, TOLBERTLM. A55kW three-phase inverter with Si IGBTs and SiC Schottky Diodes[J]. IEEE Transactions on Industry Applications, 2009,45(1):278-285.
[13]	ZHANG Z, WANG F, TOLBERT L M , et al. Active gate driver for crosstalk suppression of SiC devices in a phase-leg configuration[J]. IEEE Transactions on Power Electronics, 2014,29(4):1986-1997.
[14]	谭博, 刘卫国, 马瑞卿 , 等. 无刷直流电动机弱磁调速研究[J]. 微特电机, 2009,37(12):15-18.

[1]	李晨阳. 基于最大电流的双无刷直流舵机错峰起动控制[J]. 微特电机, 2021, 49(3): 36-39.
[2]	温嘉斌, 赵红阳, 刘子宁. 基于FPGA的无刷直流电动机容错控制系统[J]. 微特电机, 2020, 48(6): 56-60.
[3]	王家舜. 高速无位置传感器无刷直流电动机控制系统[J]. 微特电机, 2020, 48(4): 60-63.
[4]	张娟, 孙彦超, 高杨, 吴桂峰. 基于花授粉算法的无刷直流电动机速度控制研究[J]. 微特电机, 2020, 48(3): 58-60.
[5]	姚叶明,徐礼林. 航空无刷直流电动机四象限PWM驱动PI控制方法研究[J]. 微特电机, 2020, 48(2): 51-54.
[6]	王日茗, 杨建飞, 邱鑫, 王浩亮, 王志伟, 樊温新. 基于电流预测控制的BLDCM换相转矩脉动抑制方法[J]. 微特电机, 2020, 48(12): 41-46.
[7]	黄立立, 徐奇伟, 李蓬威, 杨云. 基于最小二乘法的BLDCM霍尔安装偏差补偿方法[J]. 微特电机, 2019, 47(8): 41-44.
[8]	刘细平,刘雨锋,蔡少文,张志轩. 基于端电压检测的无位置传感器无刷直流电动机研究[J]. 微特电机, 2019, 47(7): 46-50.
[9]	杨晓生,曹广忠,黄苏丹,吴超,符兴东. 三相全桥式开关磁阻电机转矩脉动抑制方法[J]. 微特电机, 2019, 47(3): 70-76.
[10]	. 无传感器永磁同步电动机转矩脉动抑制[J]. 微特电机, 2019, 47(11): 47-51.
[11]	. 基于干扰观测的动量轮高精度动态力矩跟踪控制[J]. 微特电机, 2019, 47(10): 56-58.
[12]	支康仪,武登云,史永丽. BLDCM霍尔位置传感器信号故障诊断及重构[J]. 微特电机, 2019, 47(1): 12-16.
[13]	杨秋萍,李疆,欧阳崇伟. 自适应无传感器无刷直流电动机换相控制策略[J]. 微特电机, 2019, 47(1): 63-69.
[14]	陈威,仇志坚. 基于凹函数的BLDCM滑模观测器控制研究[J]. 微特电机, 2018, 46(9): 75-79.
[15]	张兰红,唐慧雨,何坚强,孙星. 采用霍尔传感器的无刷直流电动机DTC系统研究[J]. 微特电机, 2018, 46(8): 35-39.

基于三相电流连续的无刷直流电动机驱动技术

Research on a Novel Driving Strategy of BLDCM Based on Continuous Three-Phase Current Mode

RichHTML

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

联系我们