悬浮载荷对无轴承永磁电机电磁力波及电磁噪声影响分析

微特电机 ›› 2022, Vol. 50 ›› Issue (12): 8-15.

悬浮载荷对无轴承永磁电机电磁力波及电磁噪声影响分析

周晓燕, 李德鑫, 刘广信

青岛理工大学信息与控制工程学院,青岛 266525

收稿日期:2022-08-24 出版日期:2022-12-28 发布日期:2022-12-15
通讯作者: 李德鑫(1996—),男,硕士研究生,研究方向为无轴承永磁电机特性分析及其优化设计。
作者简介:周晓燕(1978—),女,副教授,研究方向为永磁电机分析与优化设计。
基金资助:
高等学校科技计划项目(J16LN28)

Analysis of Electromagnetic Noise Under the Action of Electromagnetic Force Wave and Suspended Winding of Bearingless Permanent Magnet Motor

ZHOU Xiaoyan, LI Dexin, LIU Guangxin

School of Information and Control Engineering,Qingdao University of Technology,Qingdao 266520,China

Received:2022-08-24 Online:2022-12-28 Published:2022-12-15

摘要/Abstract

摘要： 无轴承永磁电机相比普通永磁同步电机增加了一套用于控制转子位置的悬浮绕组,产生悬浮磁场,使得气隙磁场发生畸变,改变电磁力,进而对电磁噪声产生影响。针对该问题,采用解析法推导归纳了无轴承电机电磁力波阶数和频率规律;针对交替极无轴承永磁电机,建立参数化有限元多物理场分析模型,进一步计算电磁力波的大小;通过仿真实验得出了悬浮电流大小和相位对电磁噪声的影响规律以及悬浮电流对多转速下电磁噪声的影响规律。

关键词: 无轴承永磁电机, 径向电磁力, 悬浮磁场, 集中力加载, 多物理场多转速, 振动噪声

Abstract: Compared with the ordinary permanent magnet synchronous motor, the bearingless permanent magnet motor adds a set of suspension windings for controlling the position of the rotor, which generates a suspension magnetic field and distorts the air gap magnetic field. The electromagnetic noise of the motor is affected. Aiming at the problem, the order and frequency of the electromagnetic force wave of the bearingless motor were deduced and summarized by the analytical method. A parametric finite element multiphysics analysis model was establishedfor the alternating pole bearingless permanent magnet motor, and the electromagnetic force wavewas further calculated. The influence of the magnitude and phase of the levitation current on the electromagnetic noise and the influence of the levitation current on the electromagnetic noise under multi-speed were obtained through the simulation experiment.

Key words: bearingless permanent magnet motor, radial electromagnetic force, suspended magnetic field, concentrated force loading, multi-physics multi-speed, vibration noise

中图分类号:

TM351

周晓燕, 李德鑫, 刘广信. 悬浮载荷对无轴承永磁电机电磁力波及电磁噪声影响分析[J]. 微特电机, 2022, 50(12): 8-15.

ZHOU Xiaoyan, LI Dexin, LIU Guangxin. Analysis of Electromagnetic Noise Under the Action of Electromagnetic Force Wave and Suspended Winding of Bearingless Permanent Magnet Motor[J]. Small & Special Electrical Machines, 2022, 50(12): 8-15.

参考文献

[1] 张冉,王秀和,乔东伟,等.磁极偏心削弱永磁电机激振力波方法[J].中国电机工程学报,2010,30(27):20-25.
[2] 付敏,邓佳慧,于静,等.U型单相自起动永磁同步电机电磁振动与噪声分析[J].电机与控制学报,2020,24(6):64-71,80.
[3] 李晓华,黄苏融,张琪.电动汽车用永磁同步电机定子结构固有频率分析[J].中国电机工程学报,2017,37(8):2383-2391.
[4] 钱喆,唐光华,王群京,等.转子结构优化削弱车用永磁同步电机振动噪音[J].电机与控制学报,2021,25(10):122-129.
[5] 丁强.交替极无轴承永磁电机控制系统研究[D].南京:南京航空航天大学,2010.
[6] 邢泽智.表贴式永磁同步电机电磁激振力波的快速准确计算与分析[D].济南:山东大学,2019.
[7] YANG I J,LEE S H,LEE K B,et al.Process to reduce electromagnetic vibration by reducing the spatial harmonics of airgap magnetic flux density[J].IEEE Transactions on Magnetics,2020 (99):1-6.
[8] SUGIMOTO H,KAMIYA K,NAKAMURA R,et al.Design and basic characteristics of multi-consequent-pole bearing less motor with bi-tooth main poles[J].IEEE Transactions on Magnetics,2009,45(6):2791-2794.
[9] ZHU H,LI F.Optimization design of bearingless permanent-magnet slice motor[J].IEEE Transactions on Applied Superconductivity,2016,26(4):1-4.
[10] 周晓燕.无轴承永磁电机磁场全局解析摄动法和优化设计研究[D].上海:上海大学,2015.
[11] 王晓琳,倪拓成,丁强,等.一种新型无轴承磁通切换电机原理及其实现[J].中国电机工程学报,2017,37(12):3612-3620,3690.
[12] 黄燕,王晓琳,仇志坚,等.交替极无轴承电机的转矩与悬浮特性[J].电机与控制学报,2010,14(12):91-95.
[13] 丁强,邓智泉,王晓琳.无轴承交替极永磁电机磁极形状优化设计[J].电机与控制学报,2017,21(1):69-76.
[14] 安治国,王善明,李亚坤,等.基于转子偏心的开关磁阻电机振动性能研究[J].微电机,2020,53 (7):10-16.
[15] 孙宇新,吴昊洋,施凯,等.新型双绕组无轴承磁通切换永磁电机的设计与分析[J].排灌机械工程学报,2017,35(12):1096-1104.
[16] 邓文哲,左曙光,孙罕,等.考虑定子铁芯和绕组各向异性的爪极发电机模态分析[J].振动与击,2017,36(12):43-49.
[17] LI H,ZHU H.Design of bearingless flux-switching permanent-magnet motor[J].IEEE Transactions on Applied Superconductivity,2016,26(4):1-5.
[18] SUN X,XUE Z,ZHU J,et al.Suspension force modeling for a bearingless permanent magnet synchronous motor using Maxwell stress tensor method[J].IEEE Transactions on Applied Superconductivity,2016,26(7):1-5.
[19] JI Z,ZHU H,XU Y,et al.Optimization design of permanent magnet assisted single winding bearingless synchronous reluctance motor[J].IEEE Transac-tions on Applied Superconductivity,2020,30(4):1-5.
[20] WANG H,BAO J,XUE B,et al.Control of suspending force in novel permanent-magnet-biased bearingless switched reluctance motor[J].IEEE Transactions on Industrial Electronics,2015,62(7):4298-4306.
[21] VEREZ G,BARAKAT G,AMARA Y,et al.Impact of pole and slot combination on vibrations and noise of electro-magnetic origins in permanent magnet synchronous motors[J].IEEE Transactions on Magnetics,2015,51 (3):1-4.