基于开绕组的BLDCM DTC换相转矩脉动抑制方法研究

微特电机 ›› 2021, Vol. 49 ›› Issue (5): 41-46.

基于开绕组的BLDCM DTC换相转矩脉动抑制方法研究

张永民¹, 杨建飞^1,2, 金振¹, 邱鑫^1,2, 陈秋仲¹, 吕润³, 周阳³

1.南京师范大学电气与自动化工程学院,南京 210023;
2.南京智能高端装备产业研究院有限公司,南京 210042;
3.国电南瑞集团有限公司,南京 211100

收稿日期:2020-12-30 出版日期:2021-05-28 发布日期:2021-06-09
作者简介:张永民(1997—),男,硕士研究生,研究方向为电机控制。
基金资助:
国家自然科学基金项目(51407095,51607094);江苏省自然科学基金项目(BK20151548);江苏省科技成果转化专项资金项目(BA2018035);六大人才高峰项目(GDZB-043);南京市后补助计划项目(201722046);江苏省研究生实践创新项目(SJCX20_0433,SJCX20_0436);江苏省研究生科研创新项目(KYCX20_1252)

Research on BLDCM DTC Torque Ripple Reduction Method Based on Open Winding Structure

ZHANG Yong-min¹, YANG Jian-fei^1,2, JIN Zhen¹, QIU Xin^1,2, CHEN Qiu-zhong¹, LÜ Run³, ZHOU Yang³

1. School of Electrical and Automation Engineering, Nanjing Normal University, Nanjing 210023, China;
2. Nanjing Institute of Intelligent High-End Equipment Industry Co., Ltd., Nanjing 210042, China;
3. State Grid Nanrui Group Corporation, Nanjing 211100, China

Received:2020-12-30 Online:2021-05-28 Published:2021-06-09

摘要/Abstract

摘要： 针对传统星形连接无刷直流电动机直接转矩控制下存在较大关断相续流引起转矩脉动坠落的问题,提出在断开电机绕组下通过电压矢量来实现关断相电流的抑制方法。该方法基于开绕组多维度的电压矢量分析,结合共直流母线拓扑自身多电平的优势,利用新型零电压矢量和正电压矢量的联合控制来实现关断相电流抑制并最终达到转矩脉动的抑制效果。仿真结果表明,该方法在电机正常运行的基础上可以减小关断相续流,从而达到转矩脉动抑制效果。

关键词: 开绕组, 电压矢量, 转矩脉动抑制, 无刷直流电动机

Abstract: In order to solve the problem of torque ripple drop caused by large turn-off phase continuous current in traditional star connected brushless DC motor direct torque control (BLDCM DTC), a method to suppress the turn-off phase current through voltage vector is proposed when the motor winding is opened. Based on the open winding multi-dimensional voltage vector analysis, combined with the multi-level advantages of common DC bus topology, this method uses the combination of new zero voltage vector and positive voltage vector to achieve the effect of torque ripple reduction. The simulation results show that the proposed method can reduce the freewheeling of the turn-off phase on the basis of the normal operation of the motor, so as to achieve the torque ripple reduction effect.

Key words: open winding, voltage vector, torque ripple reduction, brushless DC motor

中图分类号:

TM331

张永民, 杨建飞, 金振, 邱鑫, 陈秋仲, 吕润, 周阳. 基于开绕组的BLDCM DTC换相转矩脉动抑制方法研究[J]. 微特电机, 2021, 49(5): 41-46.

ZHANG Yong-min, YANG Jian-fei, JIN Zhen, QIU Xin, CHEN Qiu-zhong, LÜ Run, ZHOU Yang. Research on BLDCM DTC Torque Ripple Reduction Method Based on Open Winding Structure[J]. Small & Special Electrical Machines, 2021, 49(5): 41-46.

参考文献 21

[1]	VAFAIE M H,DEHKORDI B M,MOALLEM P, et al.Improving the steady-state and transient-state performances of PMSM through an advanced deadbeat direct torque and flux control system[J]. IEEE Transactions on Power Electronics,2017,32(4):2964-2975.
[2]	NOGUCHI S, DOHMEKI H. Improvement of torque ripple characteristics of double winding PMSM with using twin inverters[C]//2018 IEEE International Magnetics Conference (INTERMAG),Singapore,2018:1-5.
[3]	LEE M,KIM H,KIM J. Automatic advance angle control algorithm using anti-windup feedback voltage of PI current controller for wide range speed operation of BLDCM[C]//2018 IEEE Applied Power Electronics Conference and Exposition (APEC),San Antonio,TX,2018:837-842.
[4]	杨建飞,张亚飞,曹伟,等.无刷直流电机转矩磁链强耦合特性分析[J].电机与控制学报,2019,23(10):95-101.
[5]	曹伟.基于DTC的无刷直流电机转矩性能改进方法研究[D].南京:南京师范大学,2019.
[6]	PILLAY P,KRISHNAN R.MODELING,simulation,and analysis of permanent-magnet motor drives,Part Ⅱ:the brushless DC motor drive[J].IEEE Transactions on Industry Applications,1989,25(2):274-279.
[7]	JIAN SHI,TIE-CAI LI.New Method to Eliminate Commutation Torque[J].IEEE Transactions on Industrial Electronics,2013,60(6):2139-2146.
[8]	YONG-KAI LIN,YEN-SHIN LAI.Pulse width Modulation Technique for BLDCM Drives to Reduce Commutation Torque Ripple Without Calculation of Commutation Time[J].IEEE Transactions on Industry Applications,2011,47(4):1786-1793.
[9]	JIANG W,LIAO Y,WANG J,et al. Improved Control of BLDCM Considering Commutation Torque Ripple and Commutation Time in Full Speed Range[J]. IEEE Transactions on Power Electronics,2018,33(5):4249-4260.
[10]	杨建飞,曹伟,李德才,等.两相导通无刷直流电机直接转矩控制零电压矢量特性分析[J].电工技术学报,2019,34(23):4948-4956.
[11]	ZHU B,YANG J F,DOU Y,et al. A Torque Ripple Reduction Method for BLDCM DTC Based on Positive and New Zero Voltage Vectors[C]//2018 21st International Conference on Electrical Machines and Systems (ICEMS),Jeju,2018:484-487.
[12]	梁超,段富海,邓君毅,等.无刷直流电机转矩脉动抑制方法研究综述[J].机电工程技术,2020,49(11):20-22,170.
[13]	JUN T,LI X,LI W,et al.Research on torque ripple suppression of BLDCM method based on Cuk converter[J].IOP Conference Series:Materials Science and Engineering,2019,(533):1-7.
[14]	史兵,朱孝勇,全力,等.共直流母线开绕组的少稀土混合磁材料永磁无刷电机系统零序电流抑制策略[J].电机与控制应用,2018,45(9):25-33.
[15]	孙丹,林斌,周文志.开绕组电机系统拓扑及控制技术研究综述[J].电工技术学报,2017,32(4):76-84.
[16]	QI H,LING L,YANG T, et al. Research on the Characteristics of Open winding Brushless DC Motor[C]//2019 22nd International Conference on Electrical Machines and Systems (ICEMS),Harbin,China,2019:1-6.
[17]	罗玲,黄其,张远.开式绕组无刷电动机换相转矩脉动抑制研究[J].电气制造,2019,14(4):1-9.
[18]	杨康.开放式绕组三相永磁同步电机驱动系统研究[D].哈尔滨:哈尔滨工业大学,2016.
[19]	LIU YONG,ZHU Z Q,David Howe.Direct Torque Control of Brushless DC Drives With Reduced Torque Ripple[J].IEEE Transactions on Industry Applications,2005,41(2):599-608.
[20]	杨建飞,胡育文,刘建,等.无刷直流电动机直接转矩控制零矢量分析研究[J].微特电机,2015,43(10):5-11.
[21]	尹靖元,周冰.双三电平中点钳位开绕组电机反电动势谐波电压下弱磁控制策略[J].电工技术学报,2017,32(10):174-181.