轨道交通用永磁同步电机系统的延时补偿策略

摘要/Abstract

摘要： 针对轨道交通用永磁同步电机驱动系统多模式脉宽调制的工作特点,在低开关频率下提出一种改进的延时补偿策略来获取驱动电压信号。受系统延时影响,输出电流性能会出现如交直轴电流耦合、无效谐波干扰加大等现象。在低转速基于载波的SVPWM调制区域,设计一种自适应扰动观测器来获取逆变器非线性延时引起的q轴扰动电压。在i_d=0的电流控制策略中实时获取补偿时间估计值,并等效为三相电压补偿值作用于三相给定电压。在高转速的SHEPWM调制区域,通过对电压矢量角和调制深度的简单预测,即可消除系统计算延时的影响。通过实验对该方法进行了验证,结果表明了该延时补偿策略在多模式脉宽调制策略中的有效性。

关键词: 永磁同步电机, 多模式脉宽调制, 低开关频率, 系统延时补偿

Abstract: Aiming at the characteristics of the multi-mode PWM of permanent magnet synchronous motor drive system in rail transit electric was introduced, an improved time delay compensation strategy was proposed to obtain the driving voltage signal under low switching frequency. Affected by the system time delay, the output current performance appeared d,q-axis currents coupling and harmonic interference. In the low-speed carrier-based SVPWM modulation, an adaptive disturbance observer was designed to obtain the q-axis disturbance voltage caused by the inverter nonlinearity delay. In the current control strategy with i_d=0, the estimated value of compensation time was obtained in real time, and the three-phase compensation voltages were added to the given value. In the high-speed SHEPWM modulation, by simply predicting the voltage vector angle and modulation depth, the influence of the system calculation delay could be eliminated. The proposed method is verified through experiments, and the result shows the effectiveness of the proposed system delay compensation strategy in the multi-mode PWM.

Key words: permanent magnet synchronous motor, multi-mode PWM, low switching frequency, system delay compensation

中图分类号:

TM464

景晓东. 轨道交通用永磁同步电机系统的延时补偿策略[J]. 微特电机, 2020, 48(12): 36-40.

JING Xiao-dong. The Delay Compensation Strategy of Permanent Magnet Synchronous Motor in Rail-Transit Applications[J]. Small & Special Electrical Machines, 2020, 48(12): 36-40.

参考文献

[1] LIANG D, LI J, QU R,et al.Adaptive second-order slidingmodeobserver for pmsmsensorless control considering VSI nonlinearity[J].IEEE Transactions on Power Electronics, 2018,33(10): 8994-9004.
[2] 杨立永,翟飞,陈智刚.基于死区补偿的PMSM无传感器矢量控制方法[J].电气传动,2015, 45(12): 8-11.
[3] 李红梅,王萍.面装式永磁同步电机驱动系统无位置传感器控制[J].电工技术学报,2016,31(S1):85-91.
[4] URASAKI N,SENJYU T,UEZATO K,et al.Adaptive dead-time compensation strategy for permanent magnet synchronous motor drive[J].IEEE Transactions on Energy Conversion,2007, 22(2):271-280.
[5] KIM H S, MOON H T, YOUN M J.On-line dead time compensation method using disturbance observer[J]. IEEE Transactions on Power Electronics, 2003, 18(6):1336-1345.
[6] 陈斌,王婷,吕征宇,等.电压型逆变器非线性的分析及补偿[J].电工技术学报,2014,29(6):24-30.
[7] 吴茂刚,赵荣祥,汤新舟.正弦和空间矢量PWM 逆变器死区效应分析与补偿[J].中国电机工程学报,2006,26(12):101-105.
[8] 周华伟,温旭辉,赵峰,等.IPMSM控制系统逆变器死区效应分析与在线补偿[J].电气传动,2012, 42(1): 26-30.
[9] 韩坤,孙晓,刘秉,等.一种永磁同步电机矢量控制SVPWM死区效应在线补偿方法[J].中国电机工程学报,2018, 38(2): 620-627.
[10] 朱利东,王鑫,朱熀秋.基于NNBPF-EKF 的内置式永磁同步电机死区补偿方法[J].中国电机工程学报,2020, 40(15): 5011-5019.
[11] CHOI J W,SUL S K.Inverter output voltage synthesis usingnovel dead time compensation[J].IEEE Transactions on Power Electronics,1996,11(2):221-227.
[12] 王高林,于泳,杨荣峰,等.感应电机空间矢量PWM控制逆变器死区效应补偿[J].中国电机工程学报,2008,28(15):79-83.
[13] LIN Y K,LAI Y S.Dead-time elimination ofPWM-controlled inverter/converter without separatepower sources for current polarity detection circuit[J].IEEE Transactions on Industrial Electronics,2009,56(6):2121-2127.
[14] YANG S, CHEN G. High-speed position-sensorless drive of permanent-magnet machine using discrete-time EMF estimation[J]. IEEE Transactions on Industrial Electronics, 2017, 64(6): 4444-4453.
[15] TANG Q, SHEN A, LUO X, et al. PMSM sensorless control by injecting HF pulsating carrier signal into ABC frame[J]. IEEE Transactions on Power Electronics, 2017, 32(5): 3767-3776.